2011 Kia Sorento Problems

An engine compartment fire can occur while driving. A fire increases the risk of injury.

Fix: Dealers will install Knock Sensor Detection System (KSDS) software and replace the engine as necessary, free of charge.

The Hydraulic Electronic Control Unit (HECU) may experience an electrical short, which can result in an engine compartment fire while parked or driving. An engine compartment fire while parked or driving can increase the risk of injury.

Fix: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the HECU fuse, free of charge.

In the affected vehicles, if excessive force is applied to the gear shift lever, the brake-shift interlock mechanism may chip or crack allowing the transmission being able to be shifted out of "Park" without the brakes being depressed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 114, "Theft Protection." Without requiring the brake to be pressed, the vehicle may be unintentionally shifted out of Park, allowing it to roll, which may result in a crash.

Fix: Kia will notify owners, and dealers will replace the brake-shift interlock mechanism, free of charge.

Originally, in April 2013, Kia recalled 623,658 model year 2007-2010 Rondo and Sportage, model year 2007-2011 Sorento, model year 2007 Sedona, model year 2010-2011 Soul, and model year 2011 Optima vehicles. In September 2013, Kia informed the agency that it was adding an additional 356,719 vehicles to this campaign. The total number of vehicles being recalled is now 980,377. In the affected vehicles, the stop lamp switch may malfunction. A malfunctioning stop lamp switch may cause the brake lights to not illuminate when the brake pedal is depressed or may cause an inability to deactivate the cruise control by depressing the brake pedal. Additionally, a malfunctioning stop lamp switch may also result in intermittent operation of the push-button start feature, affect the operation of the brake-transmission shift interlock feature preventing the shifter from being moved out of the PARK position and cause the Electronic Stability Control (ESC) malfunction light to illuminate. Failure to illuminate the stop lamps during braking or inability to disengage the cruise control could increase the risk of a crash. Additionally, when the ignition is in the 'ON' position, the transmission shifter may be able to be moved out of PARK without first applying the brake. This may lead to unintentional movement of the car which may increase the risk of a crash.

Fix: Kia's recall campaign number is SC098.

The units are not water-tight and moisture can seep into the converter module and defeat the module's internal circuit protection. Without the circuit protection, the module can overheat possibly resulting in a fire.

Fix: Curt manufacturing will notify owners and replace the tow package wiring harness. The remedy will be performed free of charge.

4l engines manufactured from the start of production through may 22, 2010. The intermediate shaft may suffer from noise and excessive wear due to a misalignment of the intermediate shaft with the right side output gear. Continuing to drive the vehicle in this condition leads to the development of a whirring/whining noise and can eventually cause damage to the automatic transmission. Damage to the transmission may cause loss of motive power, increasing the risk of a crash.

Fix: Dealers will replace the right side output gear and intermediate shaft free of charge. The safety recall is expected to begin during may 2011.

Some of the rear brake calipers may not have been properly machined. As a result, brake fluid will leak, followed by illumination of the malfunction indicator light indicating the brake fluid level is low and should be checked, then a soft or spongy brake pedal feel, and if not serviced, reduced braking power which could increase the risk of a crash.

Fix: Dealers will inspect the rear calipers and replace it if necessary free of charge.

A limited number of wiring harnesses supplied by jci and used for the lighting in the kia soul vehicle's advanced lighting speakers, located in the front door trim panels, and the kia sorento vehicle's interior accent illumination, located in the front and rear door trim panels, may have been improperly soldered. When the lights are illuminated under certain conditions, an electrical short may occur that can result in a fire.

Fix: Dealers will replace the wiring harnesses for the lights in the kia soul vehicle's advanced lighting speakers, and the wiring harness for the kia sorento vehicle's interior accent illumination. This service will be performed free of charge.